Dare to use it as the DPS waterproof material (concrete protective agent) for the Three Gorges Dam, nuclear power plant and other high requirements of the United States. Impermeability level above 11! Many permanent condensates are not detected by DPS.
Do not fight price war. Ask for unlimited low price communication. Of course, the wireless low is selling water to you
U.S.A C O -MA-SEAL ® Permanent liquid DPS waterproof material - concrete protective agent
DPS, It is the abbreviation of Deep Penetration Sealer. In the definition of domestic national standards, it is water-based (or water agent, water-based) permeable crystalline inorganic waterproof material. The American CO-MA-SEAL permanent condensate DPS waterproof material was used in the United States in the 1920s, mainly for large areas of underground military bunkers, playing a role in waterproof and moisture-proof.
U.S.A C O -MA-SEAL ® Permanent condensate DPS waterproof material is Water based permeable crystalline waterproof material (The advantage of water-based is that when there is water in the concrete structure, it can continue to react until the water is "absorbed"). Its waterproof mechanism is to produce chemical reaction with free alkali and other active ingredients in the concrete, generate stable dendritic crystal colloid, effectively block the micro cracks and capillary voids in the concrete, so that the concrete structure has good waterproof function and better compactness and compressive strength. The permeability of high layer reaches about 30mm. At the same time, it can effectively prevent the erosion and damage of acid and alkali substances, oil stains, algae, salt, etc. to concrete.
It can be used for any concrete base surface. It can only be used for concrete base.
American CO-MA-SEAL permanent liquid DPS waterproof material is not only concrete waterproof material, but also concrete protective agent: it is acid resistant, alkali resistant, corrosion resistant, and can resist high temperature changes! It can also resist the damage and erosion of chloride ions on concrete.
Main performance description:
1、 American CO-MA-SEAL permanent condensate DPS waterproof material is permeable crystalline waterproof material, so leveling layer is not required. It can completely penetrate into the concrete structure, so no protective layer is required;
2、 It needs to be fully contacted with the concrete to achieve a good waterproof effect, so the laitance and dust on the surface of the concrete structure must be cleaned up first. Rapid solidification shall be used at the crack first cement Wait for repair;
3、 It is a waterproof material with small density of water agent, which can be sprayed twice on the concrete base directly without additional curing. Low construction cost and fast construction progress;
4、 The penetration degree of the high layer can reach about 30mm (general concrete). Impermeability grade reaches above S11;
5、 Good acid, alkali and corrosion resistance. It can resist the influence of temperature change on concrete. It can resist the penetration damage of chloride ion to concrete. It can enhance the compressive strength of concrete structure surface, etc;
6、 American CO-MA-SEAL permanent condensate DPS waterproof material is inorganic waterproof material, so it will not deteriorate. The effect is very stable. After construction, the waterproof efficiency is basically the same as the service life of the concrete structure;
7、 It can be constructed on the wet concrete working surface, but there should be no open water. It can be constructed on the back surface;
8、 Because it is a deep penetration crystalline waterproof material, there will be no traditional problems such as aging, untight lapping, delamination and sliding;
9、 It can play a good role in protecting concrete, reinforcement, etc;
10、 It is completely environmentally friendly and can be used as the interior wall of swimming pool, sewage pool, water plant, etc;
11、 Because it is a deep penetration crystalline type, it is not a surface sealed bead, but hydrophilic.
Special reminder: the waterproof material of American permanent liquid DPS is water agent, colorless and tasteless, so there are many counterfeits. It depends on whether there is an import declaration form, certificate of origin, etc. The permanent condensate DPS imported from the United States is * * * permanent condensate DPS. Compared with the domestic ones, the quality gap is too large and the price is absurdly low (material cost per square meter). There are many so-called English brands in the market that are counterfeit imports! Search abroad (Baidu can only search domestic) to determine whether there are relevant manufacturer websites, brands, construction cases and other materials abroad! You can also check the time when a so-called English brand registered its trademark in China at a glance! The so-called domestic production of American technology is more untrustworthy, because there is no relevant evidence!
Executive standard:
JC/T 1018-2006 Waterborne Permeable Crystalline Inorganic Waterproof Material Type II DPS
CECS 195-2006 Technical Specification for Application of Polymer Cement and Permeable Crystalline Waterproof Materials
DBJ01-54-2001 Permeable Waterproof coating Quality Inspection Standard
GB 50208-2008 Code for Quality Acceptance of Underground Waterproof Engineering
GB/T 17219-1998 Safety Evaluation Indicators for Drinking Water Transmission and Distribution Equipment and Maintenance Materials
GB 18582-2008 Interior Decoration Materials Interior wall paint Limit of medium and harmful substances
JTJ 275-2000 Technical Code for Anticorrosion of Concrete Structures in Port Engineering
Parameters:
PH value: 11 ± 1;
Appearance: colorless, tasteless and harmless;
Density: 1.07 ± 0.05;
Flammability: non combustible;
Freezing point: 0 °;
Boiling point: 100 °;
Surface tension: ≤ 36 mN/m;
Gelation time: ≤ 400 minutes; No initial setting;
High permeability: about 3cm (C25 concrete, refer to JC/T 1018-2006 Type II);
Impermeability grade: ≥ S11;
Compressive strength: ≥ high standard (refer to DBJ01-51-2001 below);
48h water absorption: ≤ 65%;
Anti permeability pressure ratio: ≥ 200%;
Frost resistance: 20 °~- 20 °, 15 times of surface without pulverization and cracks;
Heat resistance: 80 °, 72 hours, no powdering and cracks on the surface;
Alkali resistance: after soaking in saturated calcium hydroxide solution for 168 hours, the surface is free of pulverization and cracks;
Acid resistance: Soak in 1% hydrochloric acid solution for 168 hours, and the surface is free of pulverization and cracks;
Corrosion of reinforcement: no corrosion;
Chloride ion permeability resistance: ≤ 1000 C (refer to JTJ 275-2000 Specification for Concrete Corrosion Protection of Port Engineering);
Shelf life: more than 5 years;
Environmental protection: meet the standard of GB 18582-2001 Limit of Harmful Substances in Interior Decoration Materials.
Some representative projects:
Phase II dam on the right bank of China Three Gorges Dam
Beijing Hilton Hotel
All airports in Pudong, Shanghai
Workshop of Nokia (Shenzhen)
Guangzhou Evergrande Group Century Garden
Basements of Zhuhai Campus of Beijing Normal University
Australia door Sands Casino
Tsing Ma Bridge, Hong Kong
Hong Kong Disney
Beijing Metro Line 2
reference material:
Judgment on the Quality of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material, How to Judge the Quality of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material
Construction Scheme of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material
Baidu Baike "American CO-MA-SEAL Permanent Condensate DPS", "CO-MA-SEAL Permanent Condensate DPS", "Concrete Permanent Condensate", "Water based Permeable Crystalline Inorganic Waterproof Material", "Concrete Protector", etc
other Technical reference:
AASHTO - American Highway and Transportation Association
ASTM - American Standard Test for Materials
BSI - British Standards Institute
VDOT - Virginia Department of Transportation
HYD - Hong Kong Highways Department
The above is a brief introduction of CO-MA-SEAL permanent liquid DPS waterproof material (concrete protective agent). If we have any unclear information, please feel free to contact me. Wish us a happy cooperation!
Attachment: created by Li Ji, Baidu Encyclopedia:
"Permanent Condensate", "American CO-MA-SEAL Permanent Condensate DPS", "Waterborne Permeable Crystalline Inorganic Waterproof Material", "Concrete Protector", etc.
Edited and uploaded by Li Ji, Baidu Wenku:
How to Judge the Quality of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material, Judgment of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material Quality, Detailed Introduction of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material, Construction Scheme of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material, Protection of American CO-MA-SEAL Permanent Condensate DPS Waterproof Material to Concrete, Brief Comparison of American CO-MA-SEAL Permanent Condensate DPS and Other Waterproof Materials, etc.
thank you!
Sincerely
CO-MASEAL brand, CTI (American Coatings and Coating Technology Co., Ltd.) China office
American permanent condensate DPS waterproof material series products
In addition to providing high-quality waterproof materials, we also provide complete waterproof construction solutions. Our series of products are used together, and the effect is wonderful. For example, RMO, which is used in conjunction with American Permanent Condensate DPS, specially uses waterproof repair waterproof materials.
Reminder: American Yongning liquid series products are water agents, colorless, easy to counterfeit and cheat customers. Market chaos, beware of counterfeiting.
Reference materials: Baidu Encyclopedia created by Li Ji "Permanent Condensate DPS", "American Permanent Condensate DPS", "water-based permeable crystalline inorganic waterproof material", "concrete protector", "how to judge the quality of American Permanent Condensate DPS waterproof material", etc.